At which temperature is the Tick-Borne Encephalitis Virus destroyed? If there is no data specifically for TBEV, is there any data for typical temperatures at which other Flaviviruses / Flaviviridae / other similar viruses are destroyed? (Or if there's nothing specific at all, then viruses in general?)


A very basic model of virus inactivation is exponential decay.

You can describe exponential decay with the $N(t) = N_0e^{-\lambda t}$ equation, of if you want to use half-time, then with the $N(t) = N_02^{-t/t_{1/2}}$, where $N$ is the value which reduces by time, $t$ is the time, $\lambda$ is the exponential decay constant and $t_{1/2}$ is the half-life (the time required to reduce the actual value to its half).

Exponential decay looks like this on diagrams:

exponential decay

  • Figure 1 - exponential decay

exponential decay on log scale

  • Figure 2 - exponential decay on log scale is linear

In the case of your TBEV virus, the $N_0$ will be the initial virus titer, the $N(t)$ will be the virus titer by a specific time, the $t$ will be the time and the $t_{1/2}$ will be the half-life, which depends on many things; TBEV strain, temperature, dry/moist heat, pH, etc...

Now real life logarithmic diagrams of TBEV thermal inactivation are linear only by the first 30 mins or so (the inactivation is exponential during that period) as you can see on Figure 3.

virus inactivation at 60°C

By virus inactivation most of the articles like to use log 10 reduction factors. For example $3 lg$ or $3 log 10$ means in this context, that lowering the initial value to $10^3 = 1000$ fold.

According to this article most of the checked TBEV strains has an inactivation index (the reduction factor difference between two temperatures) around 1.7lg between 50°C and 37°C for 15 mins. So you need 15 mins at 50°C to reduce them at least $10^{1.7}=50$ fold. The reduction factor by this study was around 4lg by 37°C for 15mins (so the virus count reduces certainly not just because the heat, but other environmental factors).

Thermoresistance (Т50) of TBEV strains was tested by Ovchinnikova et al. method [17] using 24-hour cell culture grown in 96-hole plates at the presence of СО2. The thermoresistance was determined by inactivation index – difference in lg of titers of virus samples heated at 50°С during 15 minutes or unheated (4°С). In case of titers difference equal or less than 2.0 lg the strain was characterized as Т50+, from 2.1 to 3.0 lg – as medium, equal or more than 3.1 lg – as Т50-.

The values of lgTCD50/ml at 37ºС varied from 3.5 to 8.26. According to the thermoresistanse feature all tested strains were divided into three group: thermostable (Т50+) - nine strains; thermolabile (Т50-) – one strain; strains with medium thermoresistance – three strains. It should be noted that all strains isolated from I. persulcatus ticks collected in Krasnochikoiskiy district of Transbaikalia were thermostable.

According to another study TBEV required 6 hours of moist heat at 60°C for inactivation of 6.6 lg.

Vapor heating of a FVII concentrate in another study (which used lyophilization, followed by adding water to achieve homogenous moistening, then heating at 60°C for 10 hours, followed by heating at 80°C for one hour in an airtight container under nitrogen gas atmosphere) was evaluated for its ability to inactivate HAV, HIV-1, TBEV, PRV, and MVM. HAV was readily inactivated within one hour at 60°C (5.9 log 10 ). TBEV required six hours of this treatment for inactivation of 6.6 log 10 , and three hours were required to inactivate 6.2 log 10 of HIV-1 and 6.9 log 10 of PRV.

According to this study TBEV is considered not heat resistant, so if you are worried for example about raw milk pasteurization, then I think boiling the milk for a few minutes is enough.

Due to the lipid envelope, TBEV is readily inactivated by heat treatment, detergents and organic solvents. Even though a viremic phase is common during a TBEV infection in several animal species, foodborne infection via contaminated meat or organs is unlikely due to the fast virus inactivation at elevated temperatures.

  • $\begingroup$ Thanks! This is very interesting, definitely very relevant and I'll certainly upvote, but it doesn't quite answer my question... The "thermostable" strains are able to survive 50ºС, but how high does the temperature need to be to destroy them? The paper doesn't seem to have any data beyond 50ºС. Basically, I am looking for the minimum temperature at which it would be safe to assume that TBEV has been destroyed, regardless of strain. $\endgroup$
    – EugeneO
    Nov 17 '14 at 6:47
  • $\begingroup$ @EugeneO I don't think you get the basic idea behind heat inactivation... I'll edit my answer. $\endgroup$
    – inf3rno
    Nov 17 '14 at 9:25
  • $\begingroup$ Thanks for adding all this detail - I now realize I haven't made my question precise enough. I understand the concept of half-life / exponential decay. I guess the question I'm really trying to answer is, for a reasonably large reduction (let's say 3lg), and the most thermoresistant strain I'm likely to encounter, at what temperature do I have to treat it (given some reasonable fixed treatment time, e.g. 15min or 60min) to ensure that 3lg reduction will happen? $\endgroup$
    – EugeneO
    Nov 17 '14 at 16:55
  • $\begingroup$ ... And to add to that, I might as well ask the layman's question I'm really trying to answer. If I come back from a hike in the woods in Siberia with potentially live ticks on my clothes, and put the clothes through a wash cycle (e.g. 30min at 60 deg C), can I be reasonably assured that whatever viral particles that remain won't be enough to infect me? Is there any setting on a commercially-available washing machine (temperature, length of cycle) that will give that assurance? $\endgroup$
    – EugeneO
    Nov 17 '14 at 16:59
  • $\begingroup$ (Actually, just noticed the part about "detergents" in the last article you linked, this may be my answer... But more details would be nice, this is not a theoretical question, I actually do go for hikes in the woods of Siberia so having additional data would certainly be reassuring :) $\endgroup$
    – EugeneO
    Nov 17 '14 at 17:05

Your Answer

By clicking “Post Your Answer”, you agree to our terms of service, privacy policy and cookie policy

Not the answer you're looking for? Browse other questions tagged or ask your own question.